The URL can be used to link to this page

Home My WebLink About0096 AIRPORT ROAD - Health 6 ort Road Sewer I cct #7 5.44: Hyannis (Multiple Tenets) A 294 071 o y� I� ° r ° o e f's �I 1 i o J F + . i COMMONWEALTH OF MASSACHUSETTS } � EXECUTIVE OFFICE OF ENVIRONMENTAL AFFAIRS s DEPARTMENT OF ENVIRONMENTAL PROTECTION SOUTHEAST REGIONAL OFFICE 20 RIVERSIDE DRIVE, LAKEVILLE, MA 02347 JAINE SWIFT BOB DURAND Governor Secretary LAUREN A.LISS Commissioner August 9,2002 Mr.Robert Hurley , Sentinel Products Corporation 96 Airport Road . Hyannis, Massachusetts 02601 RE: FINAL APPROVAL OF LPA NON-FUEL EMISSIONS: Application No.: 4PO2021 Transmittal No.: W028725 Source No.: 689 Action No.: E-V7 AT: Sentinel Products Corporation 96 Airport Road Hyannis, Massachusetts 02601 Dear,Mr. Hurley: The Department of Environmental Protection, Bureau of Waste Prevention has determined that the referenced Limited Plan Application("LPA"), is administratively complete and in. conformance with current air pollution control practices. The Department approves LPA No. 4PO2021 authorizing the operation of one existing foam extrusion line and accumulator at Sentinel Products Corporation(herein referred to as "facility" or"Sentinel"), 96 Airport Road, Hyannis,Massachusetts. This LPA Approval is mi accordance with 316 CMR 7.02(1), (3), and(4)of the Air Pollution Control Regulations ("Regulations"), 310 CMR 7.00, as adopted pursuant to M.G.L. c.111,sections 142A-142K. Included as part.of the LPA Approval are the following: . • Stamped approved BWP AQ 01-B Application Form, • . Supplemental information dated July 31, 2002. • General Conditions for Non-Fuel Emissions LPAs, • Special Conditions, and • Appeal Rights. This information is available in alternate format.Call Aprel McCabe,ADA Coordinator at 1-617-556-1171.TDD Service-1-800-298-2207. `^ DEP on the World Wide Web: httpJ/www.mass.gov/dep 0 Printed on Recycled Paper .a. Sentinel Products Corp. LPA No.4PO2021 Transmittal No.W028725 August 9,2002-Final Approval Page No.2 Please review the entire LPA Approval carefully as it stipulates the conditions that the facility owner/operator must adhere to for the facility to be constructed/reconstructed/altered and operated in compliance with the Regulations. The Department has determined that the filing of an Environmental Notification Form ("BNF") with the Secretary of Environmental Affairs, for air quality control purposes, was not required prior to this action by the Department. Notwithstanding this determination,the Massachusetts Environmental Policy Act and Regulation 301 CMR 11.00, section 11.04,provide certain"Fail- 'Safe Provisions"that allow the Secretary to require the filing of an ENF and/or Environmental Impact Report at a later time. Should you have any questions concerning this FINAL;APPROVAL,pleasecontact Thomas Cushing at(508) 946-2824. Very truly yours, i John K. Winkler, Chief Permit Section Bureau of Waste Prevention W/TC/dl Enclosures ` cc: Town,of Barnstable 4 Board of Health 367 Main St. Hyannis,MA;02601 Fire Dept. 95 High School Rd. Hyannis,MA 02601 DEPBVWPBC-Boston Attn: Yi Tian(w/enclosure) DEP/SERO Attn: L.Patriarca Sentinel Products Corp. LPA No.4PO2021 Transmittal No.W028725 August 9,2002-Final Approval Page No.3 GENERAL CONIDITIONS FOR NON-FUEL)EMISSION LPAs 1. Operation-,,No person shall operate a facility constructed, substantially reconstructed, or altered pursl nt to 310 CNIR 7.02(1), (3), and(4)except in conformance with the requirements established therein and in conformance with the specific written plan approval requirements. 2. Recordkeeping-The facility owner/operator shall establish an on site recording system. All records shall be maintained up-to-date such that year-to-date information is readily available for Department examination. Recordkeeping shall, at a minimum, include: a) The initiation and completion dates for the proposed construction/reconstruction/ alteration. b) Malfunctions --A record of all malfunctions including, at a minimum: the date and time the malfunction occurred; a description of the malfunction and the corrective action taken; the date and time corrective actions were initiated; and the date and time corrective actions were completed and the facility returned to compliance. c) Records shall be maintained documenting the air contaminant emission analysis supporting the response.to-BAT AQ 01-B Section-E items la; lb, and 2. d) All records shall be kept on site for three(3)years from date of record and shall be 4 w made available to the Department upon request. 3. The Regional Bureau of Waste Prevention office must be notified by telephone or fax as soon as possible after the occurrence of any upsets or malfunctions to facility equipment, air pollution control equipment; or monitoring equipment that result in an excess emission to the air or a condition of air pollution. 4. The Department must be notified in writing within 30 days of commencement of . construction and completion of this approved installation. 5. The Department may revoke, in accordance with 310 CMR 7.02(3)(k), any plan approval if the actual construction has not begun within two years from the date of issuance or if, during the construction, the construction is suspended for the period of one year or more. 6. Reporting-Any construction, substantial reconstruction or alteration, as described in 310 CMR 7.02(1), (3), and(4) at a facility subject to the reporting requirements of 310 CMR 7.12, shall be reported to the Department on the next required source registration. Sentinel Products Corp. LPA No.4PO2021 Transmittal No. W028725 August 9,2002-Final Approval Page No.4 GENERAL CONDITIONS FOR NON-)FUEL EMISSION LPAS 7. This approval may be suspended,modified, or revoked by the Department if, at any time, the Department determines that the facility is violating any condition or part of this LPA Approval. The Department shall be notified in writing before any modification of the, facility such as a change in raw materials or an increase in production capacity that may increase emissions. 8. Opacity, exclusive of uncombined water, shall not exceed 10% at all'times during all modes. of operation, including startups and shutdowns. Visible emissions or opacity that exceeds the limits set forth in this approval shall be reported to the Department in writing or by fax within seven(7) days of the occurrence. 9. Noise from the facility during construction, initial startup and routine operation, including startups and shutdowns, shall not exceed the Department noise guidelines and shall not cause a condition of air pollution as defined in 310 CNIR 7.01 and 7.10. 10. The facility shall be constructed and operated in a manner to prevent the occurrence of dust or odor conditions that cause or contribute to a condition of air pollution as defined in 310 CNIR 7.01 and 7.09. 11. This Final Approval does not negate the responsibility of owner/operator of the referenced facility to comply with this or any other applicable federal, state, or local regulations now or in the future. Nor does this approval imply compliance with any other applicable federal, state, or local regulations now or in the future.:_ 12.. Emission Testing-The Department may, in accordance with Regulation 310 CNIR 7.13, require source emission testing("stack testing'). All emission testing shall`be conducted in accordance with the Department's Guidelines for Source Emission Testin>;and with 310 CNIR 7.13. 13. Should asbestos remediation/removal be required because of the approved construction/reconstruction/or alteration of this facility, such asbestos remediation/removal, shall be done in accordance with Regulation 310 CNIR 7.15 in its entirety and 31.0 CNM 4.00. a, Sentinel Products Corp. LPA No.4PO2021 Transmittal No. W028725 August 9,.2002-Final Approval Page No.5 SPECIAL.CONDITIONS FOR NON-FUEL EMISSION LPAS . 1. Sentinel shall not exceed the operational or emission limits identified in the table below. Operational limitations VOCEmissions VOC Content' VOC Usa e (6y weight) Pounds per Pounds per Pounds per Pounds per month year month year Extrusion 4.5% 1,230 9,800 1,230 -9,800 o eration 2. The terms "per year"and"annual"shall mean a consecutive 12-month period. I Opacity, exclusive of uncombined water, from the approved equipment shall not exceed 0% at all times. This limit applies during all modes of operation,including startups and shutdowns. Visible emissions or opacity that exceeds the above limit shall be reported to the Department in writing or by fax within severi(7) days of the occurrence. This opacity limitation supersedes the opacity limitation established in General.Condition No.8 of this Final Approval, thereby making General Condition No. 8 null and void. 4. A detailed record keeping system shall be maintained to verify compliance with all conditions of this approval: r 5. The facility shall be operated in strict accordance with the application approved herein: Should - there be any differences bet�veen-the aforementioned application and this approval letter,this approval letter shall govern. 6.. The facility shall comply with all conditions contained in'this Final Approval. Should there be any differences between conditions contained in the"General Conditions"and the conditions contained in the"Special Conditions"of this Final Approval,the"Special Conditions"shall govern. Sentinel Products Corp. LPA No.4PO2021 Transmittal No.W028725 August 9,2002-Final.Approval Page No.6 APPEAL OF APPROVAL This Approval is an action of the Department. If you are aggrieved by this action, you may request an adjudicatory hearing. A request for a hearing must be made in writing and postmarked within twenty-one (21) days of the date of issuance of this Approval. Under 310 CMR 1.01(6)(b), the request must state clearly and concisely the facts that-are the. grounds for the request, and the relief sought. Additionally, tAe request must state why the Approval is not consistent with applicable laws and regulations. The hearing request-along with a valid check payable to Commonwealth of Massachusetts in the amount of one hundred dollars ($100.00)must be mailed to: r Commonwealth of Massachusetts Department of Environmental Protection P.O: Box 4062 :. Boston, MA 02211 The request will be dismissed if the filing fee is not paid, unless the appellant is exempt or granted a waiver as described below. The filing fee is not required if the appellant is a city or town(or municipal agency), county; or district of the Commonwealth of Massachusetts, or a municipal housing authority. \ The Department may waive the adjudicatory hearing filing fee for a person who shows that paying the fee will create an undue financial hardship. A person seeking a waiver must file;together with the hearing request as provided above, an'affidavit.setting forth the facts believed to support`the claim of undue financial hardship. I i YOU.WISH TO-OPEN A BUSINESS? - 9 For Your Information: Business certificates(cost$30.00 for 4 years). A business certificate ONLY REGISTERS YOUR NAME.in town(which you must do by M.G.L.-it does not,give you permission to operate.) Business Certificates are available at the Town Clerk's Office, 1"FL,367 Main Street, Hyannis,MA 02601.(Town Hall) -DATE: 0a Z ut 6 Fill in please: i5 c-0 ✓ APPLICANT'S YOUR NAME:&V BUSINESS Y UR HOME ADDRESS: MS&H C.;V_C.1e_ 50 9 -S 61b �32-`j o 4 bay 5 TELEPHONE # Home Telephone Number NAME OF NEW BUSINESS ':. TYPE QF BUSINESS of 1 IS THIS A."HD.ME OCCUPATI ?.,_;.AYES `leave ydu 4�ean given approval from the�iuil ' g di;isyo ? YES NO ADDRESS OF f3USIN S i rr .Q� . a wYu3 MAP%PARCEL N.UM61=R -n r� w When starting a new business there are several.things you must do in order to be in compliance with the rules and regulations of the Town of Barnstable. This form is intended to assist you in obtaining the.information you may need. You MUST GO TO 200 Main St. -(corner of'Yarmouth s Rd.&Main Street) to make sure you have the appropriate permits and licenses required to legally operate your business-in this town. r ` --� 1. BUILDING COMMISSIONER'S OFFICE This individual has been informed-of any permit requirements that pertain to this type of business. Authorized Signature* COMMENTS: 2. BOARD OF HEALTH This individual h n'infor d of he pe it req irements that pertain to this type of business. Authorii ture* �. COMMENTS: " 3. CONSUMER AFFAIRS fLICENSING AUTHOR ] This individual h en info d of he.11ppinsit6 a irements that pertain to this type of business. Authorized Signature* COMMENTS: paia�ball Severe Paintball LC 1301 Sawgrass Corporate Parkway Sunrise,Florida 33323-2813 USA US:800.849.6366 Intl:954.233.1680 Fax:954.233.1681 MATERIALS SAFETY DATA SHEET May be used to comply with OSHA's Hazard Communication Standard 29 CFR 1910,1200. Standard must be consulted for specific requirements. Product Identification Product Name: Paintballs Formula: Mixture Formula WT: N/A Common Synonyms: None Product Codes: Various Labels Effective Date: September 10, 2000 Revision# Original Precautionary Labeling: Health - 0 None Flammability - 0 None Reactivity - 0 None Contact - 1 Slight Hazard ratings are 0 to 4 (0 = No hazard; 4 = Extreme hazard). Protective equipment during use: Eye and face protection. -Precautionary label statements: During use avoid contact with eyes. Hazardous Components This product is not manufactured to contain a reportable component as defined-in 29 CFR 1910.1200 Component % CAS No. Not Applicable i e p0i��bvll 1 Physical Data Ingredients: Polyethylene Glycols Plasticized Gelatin Glycerol Water ` Various food grade dyes and industrial grade pigments Boiling Point: N/A Vapor Pressure (MM HG): N/A Vapor Density (Air=1): N/A Pour Point: Approximately 7 C (45 F) Specific Gravity: 1.07— 1.14 , Evaporation Rate: ' N/A (H2O=1) (BUTYL ACETATE=1) Solubility (H2O): - " Appreciable (More than 10%) %Volatiles by volume: <5% Appearance,& odor: Colored, liquid-filled capsule. Fire& Explosion Hazard Data Flash Point(Open Cup) N/A NFPA 704M Rating: 0-0-0 Flammable Limits: Upper: N/A% Lower: N/A% Fire Extinguishing'Media: Use extinguishing media appropriate for surrounding fire. Special Fire-Fighting Procedures: Firefighters should wear proper protective equipment and self-contained breathing apparatus with full face-piece operated in positive pressure mode. Toxic Gases Produced: Carbon Monoxide, Carbon Dioxide Health Hazard Data Toxicity: No known toxicity. Carcinogenicity: NTP: No IARC: No Z List: No OSHA Reg: No Effects.Of Overexposure: Contact can cause eye irritation. Target Organs: None identified. Medical Conditions Generally Aggravated By Exposure: Damaged skin. . Routes Of Entry: Ingestion, eye contact. Emergency.And First Aid Procedures: Ingestion: If swallowed and the person is conscious, immediately give large amounts of water. Get medical attention. 2 . pmio�b011 Eye Contact: Immediately flush with plenty of water for,at least 15 minutes. Get medical attention. Skin Contact: Wash with plenty of soap and water. Reactivity Data Stability: Stabile Hazardous Polymerization: Will not occur Conditions To Avoid: Heat, flame Decomposition Products: 'Carbon Monoxide, Carbon Dioxide Incompatibles: Strong oxidizing agents, polymerization catalysts and accelerators, strong bases, strong acids. Spill & Disposal Procedures Steps to be taken in the event of a spill or discharge: Wear suitable protective clothing. Carefully sweep up and remove. Disposal Procedure: Dispose in accordance with all applicable federal, state, and local environmental regulations. Protective Equipment ` Ventilation: Use adequate general or local exhaust. Respiratory Protection: None required where adequate ventilation conditions exist. Eye/Skin Protection: Safety glassed with side-shields. Storage & Handling Precautions . Special-Precautions: Store in cool, dry, well-ventilated area in.original sealed containers. Isolate from incompatible materials. Transportation Data &Additional Information Domestic (D.O.T.)- Proper Shipping Name: Paintballs, N.O.S. (Non-Regulated) 3 i { poiisJboll Notice: Severe Paintball provides the information contained herein in good faith but makes no representation"as to its comprehensiveness or accuracy. A properly trained person using this product intends this document only as a guide to the appropriate precautionary handling of-the material. Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose. ' Severe Paintball makes no representations or warranties, either express or implied, including without limitation any warranties of merchantability, fitness for a particular purpose with respect to the information set forth herein or the product to which the' information refers. Accordingly, Severe Paintball will not be responsible for damages resulting from use or reliance upon this information. r / r J i J 1 4